• Skip to main content
  • Skip to primary sidebar

Homemade Circuit Projects

Need circuit help? Post them in the comments! I've answered over 50,000!

Blog | Categories | About | Contact | Calculators-online
You are here: Home / Inverter Circuits / 250 Watt Pure Sine Wave Inverter Circuit

250 Watt Pure Sine Wave Inverter Circuit

Last Updated on January 19, 2025 by Swagatam 32 Comments

The cost and quantity of parts necessary to develop the proposed 250 watt sine wave power inverter circuit is actually much less compared to a noisy square wave switching-type inverter circuit.

Table of Contents
  • The Oscillator
  • Setting the Frequency
  • Output Voltage
  • Transformers
  • Waveforms
  • Simple 250 Watt, 50 Hz Square Wave Inverter Circuit

Only an extra three or four tiny transistors, a some resistors and capacitors, a couple of pots and a small driver transformer are all the additional parts which are required.

A glance at the block diagram will be enough to indicate that the fundamental concept of this sine wave power inverter is extremely basic.

warning message: electricity is dangerous, proceed with caution
block diagram for the 250 Watt Pure Sine Wave Inverter

The block diagram matches one of the simple 80 meter CW transmitter circuit. Essentially, it is only the frequency that is different ; 60 Hz instead of 3.5 MHz. And producing 250 watts of sine wave ac actually becomes drastically easier with the 500,000 meters (60 Hz) as opposed to the 80 meters (3.5 MHz).

A complete circuit diagram of the 250 watt sine wave inverter is shown below. The requirements are a sine wave oscillator, a buffer amplifier, and a power amplifier.

250 Watt Pure Sine Wave Inverter Circuit diagram

The Oscillator

The oscillator could be in fact of any variety, however your best option for sensible reasons can be one particular implementing RC combinations.

Actually an oscillator involving inductor-capacitor combination as for example in the Hartley or Colpitts oscillator circuits could be incorporated at 60 Hz.

However the difficulty of adjusting the frequency to be able to adapt it to 60 Hz happens to be greatly simplified by utilizing an oscillator which has its frequency implemented using an RC network. The frequency now could be altered by simply adjusting a potentiometer.

Referring to the circuit diagram, here the 10K potentiometer in the oscillator stage permits us to adjust the frequency. Do not forget that the oscillator stage will create a sine wave.

Several RC oscillator circuits are usually built to generate square waves while some others generate a sawtooth output.

We don 't want to employ these types, simply because we may end up with an inverter which is may be a low quality modified inverter. The 3.9K potentiometer in the oscillator section is positioned to regulate the level of gain in the feed back loop. Very high gain setting using this pot might lead to extreme distortion of the sine wave.

Setting the Frequency

How could you set the oscillator frequency to 60 Hz? You can use just about any common methods for computing, just like an audio frequency is measured . You could possibly evaluate your oscillator's frequency with the mains utility line voltage frequency either by seeing Lissajous statistics with an oscilloscope or by listening to and setting the beat frequency to zero.

Or perhaps for those who have a digital frequency counter, that' the best option you can have, so use it to measure and set the frequency to 60 Hz.

Output Voltage

Besides getting the frequency correct , you should have the output voltage fairly close to the preferred range of 115 - 120 volts (or to 220V depending on the transformer). As indicated in the circuit diagram the output voltage is dependent on the adjustment of t he 4 K potentiometer which can be seen situated between the oscillator and the buffer amplifier stages.

A simple way to measure and confirm the output volts is by using a standard DMM set to the AC 500 V range and then measure the output voltage while simultaneously adjusting the 4 K pot.

Transformers

In this stage the both the transformers are ordinary 60 Hz step down transformers. The driver transformer, for instance is actually a tiny power transformer having about three filament windings.

One winding may be employed for the primary , and the remaining two in series might be used for creating the center tapped secondary.

A very common type center-tapped filament transformer could be very much appropriate for the output power transformer. With a 12 volt battery supply, you might anticipate the power amplifier transistors to generate an ac voltage of around 7-9 volts peak value or 5 to 6.5 volts rms.

It means that a 12 volt center-tapped filament transformer rated at 115 volt secondary winding output must be pretty sufficient.

The dimensions or current rating of the filament transformer depends upon the total power output you would want to generate.

A 25 ampere, 12V transformer is going to be pretty enough for generating power outputs up to 200 to 250 watts. Picking out the transistor type in the power amplifier stage also will be dependent mainly by simply how much output power you want to generate.

Waveforms

waveform image of 250 Watt Pure Sine Wave Inverter

The true waveform that can be acquired from this 250 watt sine wave inverter is slightly different from a true sine wave. As indicated in the above figure, each power transistor of this power inverter amplifier comes with an operating angle marginally lower than 180λ , that is certainly, near to a Class C type working.

A little deviation in the biasing of the transistors might pull the amplifier back to genuine Class B, however because no noises can be seen developing, this further hard work to improve the bias doesn't appear to be useful.

Simple 250 Watt, 50 Hz Square Wave Inverter Circuit

This 250 watt inverter configuration employs a regular mains transformer in reverse to generate an output of approximately 220VAC operating at around 50Hz. For this purpose, a toroidal transformer, such as the I LP 30VA model, is suitable.

simple 250 Watt square wave Wave Inverter Circuit diagram

The secondary side of the mains transformer is driven by Darlington power transistors using a 50Hz square wave.

These transistors are equipped with internal anti-parallel diodes that catch any spikes resulting from leakage reactance.

If individuals intend to create their own Darlingtons using discrete transistors, it's necessary to incorporate diodes with their cathodes oriented towards the transformer to fulfill this function.

A conventional multivibrator is responsible for supplying the base drive to the power transistors. The specified component values are designed for operation slightly above 50Hz.

Opting for a slightly higher frequency is advisable due to the risk of transformer saturation at lower frequencies.

Careful consideration of Q2 and Q3 is crucial to ensure reliable circuit operation, especially considering its substantial load. While BC212 transistors might work in some scenarios, this cannot be guaranteed.

Reliable functioning of this 250 watt inverter circuit hinges on maintaining short connections between the transformer center tap, the power transistor emitters, and C3.

You'll also like:

  • 1.  4 Simple Uninterruptible Power Supply (UPS) Circuits Explored
  • 2.  1.5V, 3V, 6V Inverter Circuit Diagram
  • 3.  Inverter Circuit with Feedback Control
  • 4.  How to Make an ATX UPS Circuit with Charger
  • 5.  Generator/UPS/Battery Relay Changeover Circuit
  • 6.  Solving Inverter “No Load Auto-Shutdown” Problem

Filed Under: Inverter Circuits Tagged With: 250, Inverter, Pure, Sine, Watt, Wave

About Swagatam

I am an electronics engineer and doing practical hands-on work from more than 15 years now. Building real circuits, testing them and also making PCB layouts by myself. I really love doing all these things like inventing something new, designing electronics and also helping other people like hobby guys who want to make their own cool circuits at home.

And that is the main reason why I started this website homemade-circuits.com, to share different types of circuit ideas..

If you are having any kind of doubt or question related to circuits then just write down your question in the comment box below, I am like always checking, so I guarantee I will reply you for sure!

Previous Post: « 5 Simple Electronic Dice Circuits Explained [Digital Dice]
Next Post: Inverter Circuit with Feedback Control »
Subscribe
Notify of
guest
guest
32 Comments
Inline Feedbacks
View all comments

Primary Sidebar

circuit simulator image

Subscribe to get New Circuits in your Email

Categories

  • Arduino Projects (90)
  • Audio and Amplifier Projects (132)
  • Automation Projects (17)
  • Automobile Electronics (101)
  • Battery Charger Circuits (83)
  • Datasheets and Components (106)
  • Electronics Theory (143)
  • Free Energy (37)
  • Games and Sports Projects (11)
  • Grid and 3-Phase (19)
  • Health related Projects (25)
  • Home Electrical Circuits (12)
  • Indicator Circuits (15)
  • Inverter Circuits (89)
  • Lamps and Lights (142)
  • Meters and Testers (71)
  • Mini Projects (46)
  • Motor Controller (64)
  • Oscillator Circuits (28)
  • Pets and Pests (15)
  • Power Supply Circuits (108)
  • Remote Control Circuits (50)
  • Security and Alarm (64)
  • Sensors and Detectors (103)
  • Solar Controller Circuits (59)
  • Temperature Controllers (42)
  • Timer and Delay Relay (49)
  • Transmitter Circuits (29)
  • Voltage Control and Protection (40)
  • Water Controller (36)

Other Links

  • Privacy Policy
  • Cookie Policy
  • Disclaimer
  • Copyright
  • Videos
  • Sitemap

People also Search

555 Circuits | 741 Circuits | LM324 Circuits | LM338 Circuits | 4017 Circuits | Ultrasonic Projects | SMPS Projects | Christmas Projects | MOSFETs | Radio Circuits | Laser Circuits | PIR Projects |

Social Profiles

  • Twitter
  • YouTube
  • Instagram
  • Pinterest
  • My Facebook-Page
  • Quora
  • Stack Exchange
  • Linkedin
  • Recent Comments

    • Swagatam on Understanding Capacitor Codes and Markings
    • Swagatam on Mains High Low Voltage Protection Circuit with Delay Monitor
    • Swagatam on 3 Phase Induction Motor Speed Controller Circuit
    • Swagatam on Smart Bathroom Exhaust Fan Controller Circuit with Sensors
    • James Williams on 3 Phase Induction Motor Speed Controller Circuit

    © 2025 · Swagatam Innovations